1. Home/
  2. Contactless data rotary joint 2x 100BASE-TX real-time full-duplex (multiplexed) inner diameter 100 mm
Contactless data rotary joint 2x 100BASE-TX real-time full-duplex (multiplexed) inner diameter 100 mm product photo Front View L
For a larger view click on the picture.

Contactless data rotary joint 2x 100BASE-TX real-time full-duplex (multiplexed) inner diameter 100 mm

637426C0007
Compare

Ethernet 100BASE characteristics

Number of 100BASE-TX Ethernet-Channels:
2
Ethernet channel:
100BASE-TX Ethernet Channel | Two signal channels over one contactless transmission channel, signals are multiplexed, no redundancy
Supported Ethernet Standards:
100BASE-TX (IEEE802.3 Clause 25), autonegotiation (full duplex only)
OSI layer operation:
Layer 1 (physical)
Supported protocols:
Real-time ethernet protocols
Multiplexer:
Time Domain Multiplexing
Ethernet Frame Loss Ratio According to RFC2544:
≤ 1 x 10⁻⁹
Measured with 64 byte frames at 99% channel utilization, corresponds to BER ≤ 1 x 10⁻¹²

Electrical characteristics

Operating connection:
Body: flying leads 25 mm² LiYCY cable, shielded, outer diameter ~3.9 mm, length 1400 mm 1)
Hollow shaft: flying leads 25 mm² LiYCY cable, shielded, outer diameter ~3.9 mm, length 1400 mm 1)
Operating voltage:
21.6 to 28.8 V DC
Operating voltage remark:
0 V DC is isolated to case ground (potential-free)
Power supply has to be a ES1 type according to DIN EN 62368-1
Operating current, max.:
0.5 A @ 24 V Supply Voltage
(Inrush current: 3 A with duration of 2 ms)
Operating current, typ.:
0.33 A @ 24 V Supply Voltage
Operating power consumption, max.:
12.0 W
Operating power consumption, typ.:
8.0 W
Operating fuses:
The circuit must be externally limited to 4 A

Mechanical characteristics

Standards:
EU Directive EMC Directive 2014/30/EU
DIN EN 55032 (Class B) (Radio disturbance characteristics)
DIN EN 55024 (Immunity characteristics)
Rotating speed, max.:
300.0 rpm
Lifetime:
20 x 10⁶ revolutions
Maintenance period:
not required
MTBF:
300000 h
Interface loads, max.:
no loads allowed
Degree of protection:
IP 60
Degree of protection remark:
sealed version
Weight, approx.:
2.3 kg
Marking:
adhesive label
Temperature of cover, max.:
71°C
customer shall assure that the temperature of the case does not exceed this value (e.g. by suitable installation with metallic contact)
Inner diameter:
100.0 mm

Environmental conditions

Operating temperature:
-30 to +71 °C
Relative humidity, max.:
95% (non-condensing)
Storage ambient temperature:
-40 to +85 °C
Storage relative humidity, max.:
95% (non-condensing)

Further remarks

Remark:
This contactless rotary joint for data transmission is a high-performance substitute for traditional data sliprings.
• no sliding contacts / no contact wear
• improved life / maintenance free
• no contact interruptions / no bit errors
• suitable for real-time ethernet protocols
• protocol independent (only using OSI-Layer 1)
• high data rates (up to 3 Gbps)
• large free inner bore
• designed for high rotational speed
• supports e.g. the following protocols:

POWERLINK
PROFINET
EtherCAT
SERCOS III
EtherNet/IP
VARAN
DRIVE-CLiQ
1):
cable length tolerance ±5%
Customs tariff number:
85437090

Downloads

637426-DS.pdf

Product data sheet – 637426C0007 – 637426-DS.pdf